INSTALLATION · ROSWELL, GA
Flush-Panel Modern White Garage Door Installation in Roswell, GA
This Roswell homeowner wanted a clean, modern face without the grid of a raised-panel door. HG Garage Door installed a 16x7 flush-panel insulated steel door with recessed trim detail, double struts for the wide span, and new high-cycle torsion springs sized to the finished door weight.
Roswell project data at a glance
| Municipality | Roswell, Fulton County, GA |
|---|---|
| Door installed | 1 × 16 ft x 7 ft insulated steel, flush panel with recessed trim |
| Finish | Satin white baked polyester, low-gloss to hide dents and glare |
| Insulation | Polystyrene core, R-value 9.0 |
| Reinforcement | Two horizontal struts — required on a 16 ft span |
| Springs | Pair of 15,000-cycle torsion springs sized to finished door weight |
| Crew and time | 2 HG technicians, 4 hours 50 minutes on site |
How HG Garage Door performed the work in Roswell, GA
- Weighed and measured the opening, then ordered springs matched to the new door weight
- Removed the old 16 ft door, track and single spring setup
- Installed new vertical and horizontal track, checking the 16 ft header for level end to end
- Bolted two struts across the door and installed nylon rollers on every hinge
- Wound a matched pair of torsion springs, balanced the door and tested auto-reverse
What is a flush panel garage door?
A flush-panel door has a smooth, near-flat face instead of raised rectangles. This Roswell door adds a shallow recessed trim line around each panel for shadow definition. The result reads modern and quiet against brick, and it hides minor dings better than a deep raised-panel profile.
- Flush panel: smooth modern face, works on contemporary and transitional homes
- Raised short panel: traditional grid, most common on Georgia brick homes
- Long panel: wide horizontal bands, a middle ground between the two
Does a 16-foot double door need two springs?
Yes. HG Garage Door installed a matched pair of 15,000-cycle torsion springs on this Roswell door. A single spring on a 16-foot door leaves no redundancy — when it breaks the door drops fast and the drums unwind unevenly, which is how cables jump and doors come off track.
How many struts does a 16-foot garage door need?
At least two on an insulated 16-foot door, and this Roswell installation received two full-width galvanized struts. Wide doors bow in the middle as they lift; struts keep the panels straight, protect the hinges and stop the opener arm from twisting the top section.
Roswell garage door questions we hear most
How long does a 16x7 double garage door installation take in Roswell?
Two HG Garage Door technicians completed this Roswell installation in 4 hours 50 minutes, including tear-out, new track, two struts, a matched pair of torsion springs, nylon rollers and safety testing.
Is a flush panel door more expensive than a raised panel door?
Usually slightly, because flush faces show any imperfection and are held to tighter finish standards. HG Garage Door quotes both profiles in the same visit so you can compare exact numbers for your Roswell opening before ordering.
Will a new door work with my existing opener?
In most cases yes, once the door is balanced and the opener force is re-tuned. If the new door is significantly heavier than the old one, or the opener is over ten years old with no battery backup, HG Garage Door will say so up front rather than after installation.
Do you paint garage doors to match trim?
Factory finishes come in a set palette, and steel doors can be field-painted with an exterior acrylic once fully cured. For this Roswell home the satin white factory finish matched the existing trim, so no painting was needed.
HG Garage Door — Roswell, GA service
1353 Riverstone Pkwy, Ste 120-259, Canton, GA 30114
(470) 999-6963 · hgservicesus@gmail.com
Mon–Fri 9:00 AM – 7:00 PM · Sat Closed · Sun 10:00 AM – 3:00 PM